Issue 39, 2017

Fabrication of a flexible UV photodetector and disposable photoresponsive uric acid sensor by direct writing of ZnO pencil on paper

Abstract

There are few reports on ZnO being used for flexible substrate based sensors. Most of the studies have documented the use different solvents or inks for the sensor fabrication, which leads to the degradation of the properties of both substrate and sensing materials. This work is the first demonstration of solvent-free direct drawing on a cellulose paper using zinc oxide (ZnO) pencil to fabricate an ultra-violet (UV) light sensor, which was further utilized for photoresponsive uric acid (UA) sensing. The transient analysis was performed for ZnO (with silver (Ag) ohmic contact) and Graphene (Gr)/ZnO (with graphene contact). The recovery time constant observed for Gr/ZnO and ZnO was 8.79 and 18.13 seconds, respectively, which is comparable to that of the photodetector fabricated using the sophisticated cleanroom techniques. The responsivity calculated for ZnO and Gr/ZnO devices under 3.9 mW cm−2 UV light illumination was found to be 4.12 mA W−1 and 6.27 mA W−1, respectively. The excellent UV sensing property of ZnO was further utilized for photoresponsive UA sensing at several concentrations ranging from 100 μM to 450 μM with a sensitivity of 1.99 m μM−1 (R2 = 0.984) and the limit of detection (LOD) of 38.4 μM. In the presence of UA, the photogenerated electrons from ZnO under UV illumination get trapped by oxygen present in UA because of its oxidation in atmospheric air. As the UA concentration increases, the oxidation of UA causes more photogenerated electron traps, which results in the further decrease in the photocurrent. Such a simple and inexpensive way for fabricating ZnO-based devices on paper holds promising applications in the field of flexible and wearable electronic devices, optoelectronic sensors, and medical diagnostic systems etc.

Graphical abstract: Fabrication of a flexible UV photodetector and disposable photoresponsive uric acid sensor by direct writing of ZnO pencil on paper

Supplementary files

Article information

Article type
Paper
Submitted
22 Jul 2017
Accepted
14 Sep 2017
First published
14 Sep 2017

J. Mater. Chem. C, 2017,5, 10231-10240

Fabrication of a flexible UV photodetector and disposable photoresponsive uric acid sensor by direct writing of ZnO pencil on paper

R. S. Veerla, P. Sahatiya and S. Badhulika, J. Mater. Chem. C, 2017, 5, 10231 DOI: 10.1039/C7TC03292G

To request permission to reproduce material from this article, please go to the Copyright Clearance Center request page.

If you are an author contributing to an RSC publication, you do not need to request permission provided correct acknowledgement is given.

If you are the author of this article, you do not need to request permission to reproduce figures and diagrams provided correct acknowledgement is given. If you want to reproduce the whole article in a third-party publication (excluding your thesis/dissertation for which permission is not required) please go to the Copyright Clearance Center request page.

Read more about how to correctly acknowledge RSC content.

Social activity

Spotlight

Advertisements